@article { author = {Hassan, Payman and R. Yousif, Ali and Omar Qarani Aziz, Dr.}, title = {EFFECT OF RE-VIBRATION TIME AND STEEL FIBER CONTENT ON THE PROPERTIES OF CRUSHED CEMENT-SAND MORTAR CONCRETE Dr.}, journal = {Al-Rafidain Engineering Journal (AREJ)}, volume = {13}, number = {2}, pages = {1-12}, year = {2005}, publisher = {College of Engineering, University of Mosul, IRAQ}, issn = {1813-0526}, eissn = {2220-1270}, doi = {10.33899/rengj.2005.45624}, abstract = {Abstract The investigation aims to study the effect of re-vibration time and amount of steel fiber on the properties of concrete made with crushed cement-sand mortar as coarse aggregate. Three mixes were prepared with 0.00, 50 and 100 percent replacement of natural gravel by crushed cement-sand mortar aggregates. Mix proportions of concrete were 1: 2: 3 by weight. The water cement ratio of 0.50 to 0.60 was used to obtain the same workability for all mixes throughout the research. The specimens were cast to investigate compressive and splitting tensile strength of concrete. The results showed that concrete made of crushed cement-sand mortar as coarse aggregate had lower workability than concrete made with natural gravel aggregate for the same water cement ratio. This reduction in workability is reduced for the richer mixes and the influence of coarse aggregate on the workability decreases with an increase in the amount of cement in the mixture. Concrete compressive and splitting tensile strength were improved due to re-vibration by about 19 percent at the peak value (about one hour after initial vibration) with volume fraction of steel fiber of about 0.5 percent. The steel fibers improve the compressive strength of concrete by about 8-11 percent and the splitting tensile strength by about 10.3 percent for the same period of revibration.}, keywords = {}, title_ar = {تأثير إعادة الاهتزاز و كمية الألياف الفولاذية على خواص الخرسانة المصنوع من}, abstract_ar = {الخلاصةيهدف هذا البحث دراسة تأثير إعادة الاهتزاز و كمية الألياف الفولاذية على خواص الخرسانة المصنوعمن مكسر مونة السمنت و الرمل كركام خشن.تم تحضير ثلاث خلطات خرسانية بنسبة 100 ،50 ،0.00 % من مكسر مونة السمنت و الرمل كبديل للركام0.6 – الطبيعي، نسبة الخلط كانت 1:2:3 لجميع الخلطات (نسبة وزنيه) و نسبة الماء إلى السمنت من 0.5للحصول على نفس قابلية التشغيل لجميع الخلطات . تم صب النماذج لغرض فحص مقاومة الانضغاط و الشدغير المباشر الانفلاقى .أظهرت النتائج بأن الخرسانة الحاوية على مكسر مونة السمنت و الرمل له قابلية التشغيل أقل من الخرسانةالحاوي على الركام الطبيعي . هذا النقصان في قابلية التشغيل يقل للخلطات الغنية بالإسمنت و تأثير ركامالخشن على قابلية التشغيل يقل عند زيادة كمية الأسمنت في الخلطة .تتحسن مقاومة الآنضغاط و شد غير المباشر الانفلاقى بنسبة 19 % عند إعادة الاهتزاز بعد مرور ساعة%11- واحدة على الاهتزاز الأولى ومع نسبة الألياف الفولاذية 0.5 % . كما تتحسن مقاومة الانضغاط بنسبة 8و مقاومة الشد بنسبة 10.3 % بإضافة الألياف الفولاذية و لنفس إعادة الاهتزاز}, keywords_ar = {}, url = {https://rengj.mosuljournals.com/article_45624.html}, eprint = {https://rengj.mosuljournals.com/article_45624_88636999f8186f319f106f4a77d4a55f.pdf} }